Readers ask: How Long Do Furnace Blower Motors Last?

How long should a blower motor last on a furnace?

The blower motor in your home or office should last anywhere from 10 to 20 years. Modern sealed bearings and sealed bushings can push the lifespan to its maximum of 20 years. Proper cleaning and maintenance can also extend your unit’s lifespan.

How do I know if my furnace blower motor is bad?

What Are Signs Your Blower Motor Needs to Be Replaced?

  1. Poor or Airflow from Air Vents. This will be the first and most obvious sign your blower motor has a problem.
  2. No Airflow At All From Vents.
  3. Skyrocketing Energy Bills.
  4. Strange Noises When You Turn on the Heat.
  5. Overheating Blower / Weird Smells.

How much should it cost to replace a furnace blower motor?

Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.

You might be interested:  Question: Who Was Tesla Motors Named After?

What causes a furnace blower motor to go bad?

Blower motor breakdown can be the result of anything from old age to failed bearings, high amp draw, electrical failure in the windings, dirt accumulation, and more. “The most common cause is dirt accumulation due to lack of maintenance,” said Tom Beaulieu, president of Bay Area Services Inc.

What does a bad blower motor sound like?

A working blower motor will operate smoothly and inaudibly. A defective blower motor will make a continuous sound noticeable by the passengers in the vehicle. It can manifest as a knocking, whirring, clunking, vibrating, squealing, or whining noise that persists until the blower motor is replaced.

Can a blower motor be repaired?

Blower Motor Replacement: When Good Parts Go Bad. There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it’s a fairly straight forward repair.

Why is my furnace running but not blowing air?

Your filter could be so saturated with dust and debris. Every modern furnace is equipped with a safety shutoff that will be tripped if your furnace gets too hot, and a clogged air filter can cause your furnace to overheat, shut itself off and give you the illusion of a furnace not blowing air.

How long does it take to replace a blower motor?

DIY or Pro Installation: It’s going to take a furnace repair technician between 45 minutes and 90 minutes to replace the motor, clean the fan, adjust the motor, test it and put the furnace back together.

You might be interested:  Question: What To Do With Non Working Large Electric Motors?

Is it hard to replace a blower motor?

If you don’t want to sweat or shiver, then find a good mechanic. The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.

How much does a new furnace cost?

How Much Does a Furnace Cost? A new furnace costs $1,500 to $6,500, depending on the model you choose. The average cost of installing a mid-efficiency furnace is $1,500 to $2,500. Mid-efficiency furnaces have an annual fuel utilization efficiency (AFUE) rating of 80% to 89%.

What happens when blower motor goes bad?

You might also hear ongoing whirring noises, or noises that change or get louder if you increase the fan speed. These are all signs of problems with the blower motor. In some cases, you may even notice smoke or smells of burning while driving, in which case you should pull over immediately.

What causes a furnace fan to stop working?

If you see or hear the fan turn on, your blower motor is not the culprit. If the fan does not start, you have a wiring issue (circuit breaker trips) or motor problem (circuit breaker does not trip). While your thermostat may be at fault, only an HVAC technician can diagnose and remedy the issue correctly.

Leave a Reply

Your email address will not be published. Required fields are marked *